Access it through the back seat if it folds down. Please refer their model A60 series manual. There are two ways to get to the fuel pump, one is underneith the car, take the gas tank down. I was given the wrong filter by the auto parts store and have seen improper listings for filters online as well. However be very careful arou … nd the working area. The gas has gushed back out at me several times. There are technical service bulletins on the brakes.
Dealer has realigned door numerous times but problem continues. This is a problem that Nissan needs to take care of before someone is seriously injured or killed! Now press both side of the lock and giggle a little slide toward the back of the car and tilt up the filter end then you should be able to remove it ou of the tank. Make sure they are tightened with specific torque. Non-critical components like gas evaporator sensors, power steering sensors, air conditioner sensors. If you're looking for a quality replacement, visit your local AutoZone, where our friendly staff offers expert advice and gets you the right products at the right prices. Disconnect only the smaller one. I would find it satisfactory if Nissan redesigned and fixed all vehicles by separating circuits with critical engine components from non-critical components.
Then check under the van if there is any leakage. Before you have a try start, double check if all fuel lines are securely connected and tightened. All of a sudden I lost all power and the truck went dead. They also said because of the low fuel pressure that both of the front converters were damaged and were now failing. Make sure they are not loose.
The thing is these fuel rails leaks the fuel on the engine and I know Nissan knows this. The rear end of the tank should be lowered. Jack up the rear of the van. Reconnect the hose to the gasoline filler. I had both of the converters replaced and the problem was still there. The bolts should be loosen a little at a time in multiple turns. Reconnect each short hose back to different pipes as shown in picture to block the pipes.
I have researched this topic online in forums and have found that this is a common problem with 2004 through 2007 Nissan Titans. They have been repaired three times and are still not correct. Very few failures existed with this design. If necessary use a pair of pliers to make the connectors tighter. The dealership replaced the fuel tank and the fuel sending unit. Eventually brakes were replaced by dealer 6 months after the initial problem.
Screw back the 6 bolts after making sure the O ring is in right place. Put the electrical wire into holders. For more specific instructions on fuel tank removal for your specific vehicle it may be necessary to obtain an approved service manual for the vehicle that you are replacing the fuel pump on. This is explained very well under the question where is the fuel pump and filter located for a 1996 Nissan altima. Once the pressure build up it stops leaking that why I could never see the fuel leaking, until one morning I cranked up with the hood up. The critical design flaw comes into play when vehicle designers combine other electronic sensors on the same circuit as the gas pedal.
Found out the next day that my tank was completely empty and the gauge was wrong. You will see a square metal pla … te usually black with 4 Philips head screws. According to a Hyundai tech bulletin issued Jan 2006, service manuals were published wrong. Then reconnect the fuel lines and make sure every fastener is tight. The contact stated that the fuel sending unit failed and was causing inaccurate fuel level readings. The tank has been replaced and still does this. Nissan refuses to admit this is a significant safety issue.
Also detach the electrical wire holders. Nov 2003 edition, rev-April 2004, pub no. Note that two connectors are in different sizes, so that you will not be able to reconnect to a wrong terminal. Nexy, take a floor jack and place it underneath the gas tank and raise it up far enough to make contact with the gas tank. If it has one third or less full, you can leave it in the tank. ¿ I have searched the internet and have found dozen of incidents where this has happen to other owners and the problem seems to stem from a fuel pump problem on the 2004 Titan.