Then I discovered that if you take a one inch section for fuel hose and slide it over the stud it will hold the linkage on. Can you replace the part where the axle fits into the transmission transaxle I guess. Totally lost as to what is causing such a loud scraping, rumbling noise is. SeatingFilter selectedSeatingList, null ; seatingFilter. The car has to be raised in the air,as there is a steel plug in the trans case that has to be removed to check the fluid level. There's also a bearing right inside of that bushing that the differential assembly rides on. I kept the lip side of the bushing facing the pin from the lever as I was not sure it would be long enough to reach and secure from the other side.
There is no dip stick on the transmission any longer. I already replaced the hub assembly and the axle. Buying a used Pontiac Sunfire transmission from a non-reliable dealer is an unnecessary risk. In its final model year, the Sunfire was only available in a two-door model. You will need a transmission funnel to add to it if fluid is need. This kit only includes one bushing.
Good luck Aug 29, 2008. The Pontiac Sunfire was a compact car originally available in coupe, sedan and convertible; it was manufactured form 1995 to 2005. There is no fluid leaking from the seal, but the axle wobbles quite a bit. If so, the fluid level is correct. But, I now have a photo of my problem. A lot of people set the vehicle on the ground so the wheel won't turn and they can tighten the nut.
Saw some units that caught my eye. Our primary problem is that Pipes does not trust their customers because they will deal in cash or debit cards only; no personal checks are accepted for items that cost several thousand dollars. The numbers listed on top were 5074045. The 3 speed is designated the 3T40,the 4 speed auto is the 4T40E trans. I couldn't and will not be removing the master cylinder because 1.
Our 1998 Pontiac Sunfire repair manuals include all the information you need to repair or service your 1998 Sunfire, including diagnostic trouble codes, descriptions, probable causes, step-by-step routines, specifications, and a troubleshooting guide. The 3 speed is designated the 3T40,the 4 speed auto is the 4T40E trans. I believed I used the second to smallest one. When done,replace the plug and cap. If no fluid drips out,add fluid through the top of the trans after removing the red plastic cap,and make sure to use a long funnel to avoid a mess.
Changing break fluid in Pontiac Sunfire 1998 is also is a simple task. I don't have weeks and weeks to wait for a part that might not fit. Both models experienced frequent problems. Dorman 14041 from Autozone worked on my 2002 Cavalier. DealRatingFilter selectedRatingList, null ; ratingFilter. I tried making my own out of half inch dowels.
A pile of great info. The problem is you can't go by where the noise sounds like it's coming from. Check also our Pontiac Sunfire manual transmission catalog. I'm hoping that is the problem. Basically what they will cause is a wobble in the steering wheel during acceleration at lower speeds.
I fixed mine by myself. Also, the noise is even more evident when you have a passenger over in the right side seat. This is a the second Sunfire we've owned. You will have to go under the car to check. The washer and clip are in the hardware section of your Home Depot.